Hi Nelson,
I'm guessing that you need to double check the power and ground circuits for
the starter. Ensure the cables and the connections for both ground and
power are good at the starter, battery, and the altenator. Take each one
off and clean them thoroughly with a wire brush.)
I had a similar issue on my mothers car years ago and it turned out to be a
ground connection that visibly looked fine, but it had a lot of corrosion
under the bolt.. Once hot there was too much resistance and it wouldn't
start. Cables can also corrode internally as well - so watch for that.
If that solves the issue, you might want to test your old starter as well
with direct 12V source - since the issue may have been connections/cables
all along.
Rabin
From: peugeot-L@yahoogroups.com [mailto:peugeot-L@yahoogroups.com] On Behalf
Of Nelson Fabian Daquioag
Sent: July 26, 2006 12:02 PM
To: peugeot-L@yahoogroups.com
Subject: [Peugeot-L] Peugeot 604 - Starter motor & alternator compatibility
Hi all.
I just got an '82 604 SL v6 and I am working on my starter and
altenator.
- The original Ducellier 6238 motor starter is too weak to crank
the car, so I bought a bosch version intended for volvo 264 since
the share the same PRV engine platform. I add a relay to the
ignition switch to have enough charge to crank the motor. It works
fine.. until the engine reach the working temperature. If I switch
off the
igniton, I just won't start until half an hour or more. When its
cooler it cranks again as if nothing happened. Wiring is Ok, I have
it wired as drawn like in the 604 workshop manual. Is the bosch
starter incompatible with the original Ducellier?
- My pug's 70 amp alternator have charging problems. It hat a cut
out
module and when the car runs, the battery went dead after an hour
drive. Ok, I know.. bad alt. A friend of mine lent me a pug 405
alternator with built in voltage regulator IC. My question is, what
is the output of a 405 alt? Appreciate for help.
Thanks,
Nelson Fabian D
Peugeot 504 Indonesia Community
'75 504 GL (R.I.P.)
'82 604 SL V6
[Non-text portions of this message have been removed]
Recommended format for your email subject lines:
Model # [Model Letters] Year Subject
Examples:
505 88 V6 Mileage
405 Mi16 89 Ignition Coil source?
To unsubscribe from this list send a blank email message to PEUGEOT-L-UNSUBSCRIBE@EGROUPS.COM
Yahoo! Groups Links
<*> To visit your group on the web, go to:
http://groups.yahoo.com/group/peugeot-L/
<*> To unsubscribe from this group, send an email to:
peugeot-L-unsubscribe@yahoogroups.com
<*> Your use of Yahoo! Groups is subject to:
http://docs.yahoo.com/info/terms/
Received on Wed Jul 26 14:25:04 2006
